Ireland Biogas Growth Must Focus On Efficiency

Ireland Biogas Growth Must Focus On Efficiency
5 Oct 2022  |
Recent comments by ADBA chairman Chris Hunhe and Irish environment minister Eamon Ryan are positive for the expansion of renewable, green biogas production across the island of Ireland, but to maximize the benefits of increased anaerobic digestion capacity, operating efficiency and the use of digestate must be fully considered.

Speaking at a recent Joint Oireachtas Committee meeting on energy security and energy prices, Mr. Ryan stressed the importance of biogas to the Republic’s energy plans, with a target of 5.8 TWh of energy from biomethane and anaerobic digestion, being produced from a mixture of grass, food waste, and slurry.

Mr Ryan said, “If I recall correctly, that could involve up to 210 anaerobic digestion sites. That could provide about 15% of our gas needs and would give us some security. Anaerobic digestion has huge benefit potential for Irish farming because it gives a diverse and separate income and builds on what we are good at, which is growing grass.”

Meanwhile, at a recent event in Belfast, Chris Hunhe commented, “Northern Ireland is the best-placed part of the UK to produce the most biogas and biomethane. It has the potential to meet 80% of its gas demand from this home-grown, cost-effective, and sustainable source thanks to the importance of livestock farming.”

HRS welcomes this ambition to increase biogas production capacity on both sides of the border, but to maximize the greenhouse gas savings from these plants, it is important to also maximize the efficient use of the high-quality digestate biofertilizer produced during the AD process, as well as maximizing biogas production.

HRS Heat Exchangers provides two systems specifically aimed at improving the efficiency of digestate production and maximizing its value in both nutritional and economic terms.

Digestate Concentration

The HRS DCS uses patented technology to remove up to 80% of the water contained in the liquid fraction and concentrates it to 20% dry solids while, at the same time, maximizing the nutrient content, using heat from the AD plant’s CHP engine. Less water also means reduced road and field traffic, bringing further benefits in terms of reduced compaction caused by the application of the digestate to land. The DCS is virtually self-sufficient – minimal energy or water is bought in, nothing is wasted, and the surplus energy from the CHP is re-used up to four times.

Another benefit of the DCS is odor control, which helps increase the nutrient content of the digestate. The high temperatures needed to concentrate digestate can cause the release of ammonia, largely responsible for the odors associated with digestate. However, the DCS overcomes this by acid-dosing the digestate with sulphuric acid, thereby decreasing the pH levels. This turns the ammonia into ammonium sulfate, which is not only less odorous but is also an ideal nutrient.

Digestate Pasteurisation

To prevent the spread of potential pathogens which may be present in wastewater, either the feedstock or the digestate should be treated appropriately, with pasteurization being a tried and tested technique. One of the most energy-, and therefore cost-efficient methods to pasteurize digestate is the HRS Digestate Pasteurisation System (DPS), which is based on heat exchangers rather than tanks with heating jackets. Using heat exchangers means that effective digestate pasteurization is possible using surplus heat while allowing additional thermal regeneration levels of up to 60%. This saved heat can then be used for other processes, such as evaporation of the digestate to remove water.

The DPS and DCS are examples of several systems that HRS produce to improve the efficiency and sustainability of biogas plants and the anaerobic digestion process, with other examples including systems to dry biogas and recover waste heat from exhaust systems. Making biogas plants across the island of Ireland as efficient as possible will not only increase the environmental benefits they provide but will also improve economic returns for developers and operators, helping to increase the deployment of this vital technology.

Share this article

This article is published by

HRS Heat Exchangers is part of the HRS Group which operates at the forefront of thermal technology, offering innovative heat transfer solutions worldwide across a diverse range of industries. With more than 40 years’ experience...

Related Articles